Ford Mustang Recall: Why Nearly 150,000 Pony Cars Risk Sudden Power Loss

Ford is recalling roughly 150,000 recent-model Mustangs because engine vibration can snap brittle electrical terminals, triggering an abrupt loss of propulsion. Authorized dealerships plan to install redesigned standoff eyelet pigtails to resolve the out-of-plane bending stress.

Ford Mustang recalled for wiper fault

Ford issued a recall for nearly 5,000 newer Mustang models due to a manufacturing fault that causes windshield wipers to either fail or operate only at high speed. The defect involves a malfunction in the windshield washing system that severely limits driver visibility in poor weather.

Ford Fired Two-Thirds Of The Bosses Who Said Its Trucks Were Good Enough

CEO Jim Farley revealed that Ford replaced two-thirds of its industrial leadership team following a problematic Super Duty launch that cost the company millions in repairs. The management overhaul targets a corporate culture that Farley claims had become too comfortable with mediocre quality standards.

Six Ford Explorers Need New Engines As Their Originals Might Blow Up

Ford is recalling a small batch of 2026 Explorers after identifying engine rod bearings that were improperly polished during a specific 30-minute production window. The defect can lead to catastrophic engine failure and potential engine block breaches, requiring a complete long block replacement for affected vehicles.

NHTSA Opens Ford Maverick Hybrid Braking Petition

Federal regulators have opened a defect petition to investigate reports of intermittent braking loss in approximately 82,040 Ford Maverick Hybrid pickups. The probe follows a consumer complaint alleging that the e-boost brake-by-wire system failed to stop the vehicle during a collision event despite multiple prior repair attempts.

NHTSA investigates Ford Maverick Hybrid braking

The NHTSA has opened an investigation into 82,040 Ford Maverick Hybrid trucks from the 2024 model year following reports of intermittent braking failure. The probe was triggered by a petition alleging that the vehicles suffer from a loss of anti-lock and regenerative braking, leading to at least one crash.

Ford Explorer engine recall

Ford is recalling a small group of 2026 Explorer SUVs due to a manufacturing defect in the crankshaft polishing process that can lead to catastrophic engine failure. The company traced the issue back to a specific 30-minute production window at the Dearborn Engine Plant.

Ford Hires NHTSA Veteran, Hopes To Get Rid of Recalls and Fines

Ford has appointed former NHTSA director David Hines as its new Chief Auto Safety Officer to oversee global product compliance and safety strategy. The move aims to navigate intensified federal oversight following a $165 million penalty and a multi-year record of leading the industry in recall volume.

NHTSA says 135,000 older Ford vehicles have unreasonable safety risks; Fiesta, Focus, EcoSport affected

NHTSA has upgraded its investigation into timing belt failures in certain Ford models to an engineering analysis, citing an unreasonable risk of sudden engine seizure and power loss.

Ford recalls more than half a million Broncos due to engine fire risk

Ford is recalling over 565,000 Bronco and Bronco Raptor vehicles from the 2021-2026 model years because an inadequately protected wiring harness can short circuit and ignite a fire in the engine compartment.

Ford recall Explorer Aviator seats 2026

Ford has recalled approximately 388,000 Explorer and Lincoln Aviator vehicles because the second-row seats may fail to latch properly. This defect can cause the seats to tip or slide unexpectedly during a collision, significantly increasing the risk of injury to occupants.

Ford Recalls 565,691 Bronco and Bronco Raptors for Fire Risk

A massive recall has been issued for over half a million Ford Bronco vehicles due to an engine compartment wiring harness that lacks sufficient abrasion protection. The harness can chafe against other components, leading to electrical shorts that may ignite fires in the engine bay.

2024 Ford Explorer recall rollaway risk

A recall has been issued for 2024 Ford Explorers equipped with 2.3L engines because a software error can cause an unintentional powertrain control module reset. This glitch can damage the park system, potentially leading to vehicle rollaways even when the gear is set to 'Park.'

Ford's CEO Still Isn't Satisfied With Brand Quality

Despite ongoing efforts to improve manufacturing and testing, Jim Farley maintains that Ford's quality levels are not yet where they need to be following a year of industry-leading recall volume.

Ford to recall over 110,000 US vehicles over wiper, pinion shaft issues, NHTSA says

Ford is issuing two separate recalls covering over 110,000 Mustang vehicles to fix problems related to malfunctioning windshield wipers and a rear differential pinion shaft.

Ford recalls more than 177,000 vehicles over faulty wiper, drivetrain and other issues

Ford has issued three separate recalls affecting over 177,000 vehicles, including the Mustang and Lincoln Nautilus, to address defects involving windshield wipers, drivetrain components, and pedestrian warning systems.

Ford to recall more than 741,000 U.S. vehicles due to park system issue, NHTSA says

Ford is recalling over 741,000 vehicles, including various Explorer, Expedition, and Lincoln models, due to a park system defect that has been linked to multiple reports of property damage and injuries.

Ford to recall over 741,000 US vehicles due to park system issue, NHTSA says

Federal regulators reported that Ford is recalling over 741,000 trucks and SUVs due to defective transmission parking pawls that can fail and allow vehicles to roll away.

Ford recalling 741,000 vehicles, including F-150 models, because of transmission issues

Ford is recalling over 741,000 vehicles across several models, including the F-150, Explorer, and Expedition, due to a transmission defect that can damage the parking system. This failure increases the risk of the vehicle rolling away unexpectedly.

Ford to recall over 741000 US vehicles due to park system issue, NHTSA says

Ford is initiating a recall for over 741,000 vehicles in the U.S. to address a transmission defect that could damage the park system and potentially cause vehicles to roll away.

Ford Recalls Thousands of F-150 Trucks Over Software Update Issues

Over 10,000 Ford F-150 trucks from the 2018 model year are being recalled after previously recorded software fixes failed to properly install, leaving vehicles prone to transmission sensor faults and unintended movement. Ford dealers must re-flash the powertrain control module software free of charge.

Ford recalls nearly 45K F-150s over incomplete prior recall repair

Ford is recalling nearly 45,000 model-year 2014 F-150 trucks after finding that a prior powertrain software update was improperly documented as completed when it was not. Without the update, the vehicles risk an abrupt and unexpected downshift into first gear while driving.

Part 573 Safety Recall Report 26V373

NHTSA documentation shows Ford recalled over 91,000 F-150 trucks whose Body Control Module software was improperly applied during an earlier recall remedy. The defect causes daytime running lights to remain fully bright instead of dimming to parking lamps, violating federal lighting standards.

Ford recall for seat belt issue and a do-not-drive order for some Bronco Sport and Maverick vehicles

Ford recalled almost 420,000 full-size SUVs for locking seat belt retractors while also handing down urgent do-not-drive notices on select Maverick and Bronco Sport vehicles over disconnecting front control arms.

Nearly 420,000 top-selling Ford vehicles to be recalled: NHTSA

Ford is recalling nearly 420,000 SUVs due to a seat belt pretensioner defect that could increase injury risks during a crash.

Ford recalls over 140K pickup trucks over wiring fire risk

Ford is recalling over 140,000 Ranger pickup trucks from the 2024-2026 model years due to improperly positioned wiring harnesses that can short circuit and cause fires in the A-pillar area.

Ford recalls 1.4 million F-150s over downshift defect

Ford issued a recall for nearly 1.4 million F-150 trucks from the 2015-2017 model years due to a transmission defect that can cause an unexpected downshift into second gear. The issue stems from degraded electrical connections that disrupt communication between the transmission sensor and the powertrain control module.

Ford recalls about 1.4 million pickup trucks over gearshift issue, NHTSA says

Federal regulators prompted a recall of roughly 1.4 million Ford F-150 trucks to address unexpected transmission downshifts tied to degrading sensor connections. Dealerships will recalibrate powertrain control module software to stop the trucks from suddenly dropping gears while in motion.

Ford recalls 254,640 SUVs over driver-assist software issues

Ford is recalling more than 254,000 SUVs across Ford and Lincoln nameplates because image processing software can trigger an unplanned reset. This failure shuts off backup camera displays and disables critical driver-assistance systems including lane-keeping and blind-spot monitoring.

Ford recalls more than 250,000 SUVs for software issues, NHTSA says

Ford is recalling over 250,000 SUVs, including Lincoln and Explorer models, to fix a software glitch that can cause the loss of rearview camera images and advanced driver assistance features.

Ford recalls 1.74 million vehicles over rearview camera software glitches

Nearly 1.74 million Ford and Lincoln vehicles are being recalled after software glitches were found to cause backup camera displays to go blank or display upside-down images. Regulators noted the defect increases crash risks when backing up, requiring software remedies across multiple model lines.

Ford to recall 1.74 million vehicles in US over rearview camera issue, NHTSA says

Ford is recalling approximately 1.74 million vehicles due to software glitches that cause rearview camera displays to fail or show inverted images. The recall affects various 2020-2026 models and follows ongoing scrutiny of the company's camera systems.

Ford recalls more than 615,000 US vehicles over wiper, driveshaft defects

Ford issued two major recalls covering over 615,000 vehicles to address windshield wiper motor failures and potential rear driveshaft separations that could lead to a loss of power.

Ford recalling 4.3 million US vehicles over software issue

Ford has issued a massive safety recall covering roughly 4.3 million trucks and SUVs due to an Integrated Trailer Module software glitch. The malfunction can sever communication between the vehicle and a towed trailer, causing external trailer lighting and braking functions to fail.

Ford CEO Jim Farley’s 2024 pay falls after missed EV, quality targets

Jim Farley saw a reduction in his 2024 total compensation package, directly attributed to the company's failure to meet established internal quality and performance benchmarks.

Ford recalls 116,000 vehicles over engine block heater fire risk

Safety regulators warned that engine block heaters in certain 2.0-liter Ford and Lincoln vehicles could crack and short circuit when plugged in, resulting in 12 reported fires. Ford will notify owners in February with interim guidelines while a newly redesigned heating unit is readied for replacement by April.

Ford recall: Over 119K cars pulled related to engine heater fire risk, NHTSA says

Ford is recalling more than 119,000 vehicles in the U.S. due to engine block heaters that can crack, leak coolant, and cause electrical short circuits that lead to fires. Regulators and the automaker advised owners to refrain from plugging in the heaters until replacement parts are installed or refunds are provided.

Ford recalls some 119,000 vehicles due to engine block heater fire risk, NHTSA says

Ford issued a recall for approximately 119,000 vehicles because defective engine block heaters may crack and leak coolant, creating a fire hazard when plugged in.

Ford recalls thousands of vehicles due to battery failure

Ford is recalling over 20,000 Escape and Lincoln Corsair plug-in hybrids because a manufacturing defect in high-voltage battery cells could cause short circuits and potential fires.

Ford to recall nearly 230,000 US vehicles over instrument panel display failure, NHTSA says

Ford is recalling approximately 230,000 vehicles in the United States due to a technical failure affecting the instrument panel display.

Robbins Geller To Steer Ford Investors' Warranty Costs Suit

A federal court has appointed Robbins Geller Rudman & Dowd LLP to lead a class action lawsuit alleging that Ford executives misled investors regarding the company's escalating warranty expenses. The suit claims these hidden costs contributed to a significant drop in Ford's stock price.

Ford recalls over 1M vehicles for defective backup camera software

A massive recall of over one million Ford and Lincoln vehicles was initiated due to SYNC4 software glitches that cause the infotainment screen to freeze or black out in reverse. The company identified hundreds of warranty claims related to the sequencing error within the wireless communication subsystem.

NHTSA launches safety probe of Ford’s BlueCruise

Federal safety regulators have opened a safety investigation into Ford's hands-free driving system, BlueCruise, following nighttime highway crashes involving Mach-E vehicles. NHTSA noted system limitations in detecting stationary vehicles at highway speeds as a central factor in the crashes.

Ford to recall over 270,000 US vehicles over battery concern, NHTSA says

Ford is recalling over 272,000 Bronco Sport and Maverick vehicles due to 12-volt battery degradation that can lead to a sudden loss of drive power or electrical accessory failure.

Ford was plagued by recalls in 2024

Ford faced a challenging year in 2024, issuing 62 separate safety recalls affecting over 4 million vehicles. Despite CEO Jim Farley's stated focus on quality improvements, the company remains near the top of the industry for total recall volume.

Ford to change its quality leader as it chases lower warranty costs

Ford is restructuring its quality management team to address a persistent surge in recalls and warranty expenses that have significantly impacted the company's financial performance.

NHTSA investigates over 560,000 Ford vehicles

The National Highway Traffic Safety Administration has launched probes covering more than 560,000 Ford vehicles regarding recall remedy execution. The investigations follow a $165 million penalty requiring Ford to audit its prior safety filings after leading the industry in recalls.

U.S. regulators open 2 investigations into Ford recalls just days after penalizing the company

Federal safety regulators have initiated two new investigations probing Ford's handling of safety recalls shortly after slapping the automaker with a historic civil penalty. The agency is examining whether Ford moved quickly enough and provided full disclosures regarding vehicle defects.

Ford Consent Order; $165 Million Civil Penalty

Federal regulators hit Ford with a $165 million fine for failing to act quickly enough on rearview camera recalls and providing inaccurate data. The penalty requires Ford to overhaul its safety data monitoring and internal recall processes.

Warranty spend weighs on Ford’s Q3 profit

The automaker reported that high warranty expenses and manufacturing costs offset gains in vehicle quality, leading to a year-over-year decline in third-quarter profit.